Reliability Optimization of Co-phase Power Supply Device Based on Frequency Conversion Control Strategy
-
摘要:同相供电技术能有效解决牵引供电系统普遍存在的过分相问题和电能质量问题. 为了保障同相供电系统的安全可靠运行，作为系统的核心设备，同相供电装置的可靠性优化研究至关重要. 针对同相供电装置特殊的变流器拓扑结构，建立可靠性评估模型，分析了牵引负荷特性及主要电气参数对装置可靠性的影响机理；建立以功率模块失效率最低为目标的变频控制优化模型，采用遗传-粒子群混合算法，得到了最优变频控制策略. 研究表明：改变不同负荷区段内变流器的开关频率，可以有效降低功率元件失效率. 最后以山西中南部铁路应用的工程样机为例，基于实测数据和对比分析，表明在变频控制策略下，装置寿命可增加20.90%，可靠度增长率最大可达到54.17%，证明了变频控制策略可以有效提高装置可靠性.Abstract:Co-phase power supply technology can effectively deal with the obstacles in neutral-section passing and power quality common for the traction power supply system. In order to ensure the safe and reliable operation of co-phase power supply systems, the reliability optimization of the co-phase power supply device is very important due to its crucial role in the whole system. Thus, a reliability evaluation model is established in view of the special converter topology. Further, how traction load characteristics and main electrical parameters affect device reliability is analyzed. This work finds that altering switching frequency of the converter in different load sections can effectively reduce the failure rate of power components. The variable frequency control optimization model is established with the lowest failure rate of power modules. The optimal frequency conversion control strategy is obtained by the hybrid genetic algorithm-particle swarm optimization (GAPSO). Finally, an engineering prototype applied in Center-South Shanxi Railway is used for data measurement and comparative analysis, indicating that by the use of the frequency conversion control strategy, the device lifetime can be increased by 20.90%, and the growth rate of reliability can reach 54.17%. This proves that the frequency conversion control strategy can effectively improve the reliability of the co-phase power supply device.
-
图 2功率循环失效周期数与Tjm和ΔTj的关系
Figure 2.Relationship between number of power cycle failure cycles and ΔTjwith differentTjm
图 4牵引负荷功率因数与功率元件失效率之间的关系
Figure 4.Relationship between traction load power factor and power component failure rate
图 5开关频率与功率元件失效率的关系
Figure 5.Relationship between switching frequency andpower component failure rate
图 6IGBT模块失效率最小优化模型GAPSO算法流程
Figure 6.GAPSO algorithm flow for optimization model of minimizing IGBT module failure rate
图 10优化前牵引侧失效率与平均结温和结温波动的关系
Figure 10.Relationships between failure rate of traction side，average junction temperature and junction temperature fluctuation before optimization
图 11优化后牵引侧失效率与平均结温和结温波动的关系
Figure 11.Relationship between failure rate of traction side，average junction temperature and junction temperature fluctuation after optimization
图 12不同策略下同相供电装置可靠度曲线
Figure 12.Reliability curves of co-phase power supply device with different strategies
表 1同相供电装置参数
Table 1.Parameters of co-phase power supply device
参数 数值 额定容量/ （MV•A） 5 电网侧输入额定电压/ kV 10 牵引侧输出额定电压/ V 680 电网侧开关频率/ Hz 400 牵引侧开关频率/ Hz 1 500 
下载:
导出CSV
表 2IGBT模块参数
Table 2.Parameters of IGBT module
项目 电网侧 牵引侧 型号 SKiiP 1513 GB172-3DL V3 SKiiP 2403 GB172-4DL V3 fsw_lim/Hz 9 000 7 000 ton+off/μs 2.8 2.8 Esw_T/mJ 863 780 Esw_D/mJ 128 144 下载:
导出CSV
表 3GAPSO算法优化结果
Table 3.GAPSO algorithm optimization results
元件 Ich/A fsw_ch/Hz 变频优化前 变频优化后 maxTjm/℃ max ΔTj/℃ IGBT模块失效率/Fit maxTjm/℃ max ΔTj/℃ IGBT模块失效率/Fit 电网侧 IGBT 365 1 096 92.52 38.25 442.21 92.52 36.76 309.80 FWD 108.93 50.14 108.83 48.55 牵引侧 IGBT 366 2 652 113.47 52.64 1 127.48 113.47 50.45 705.27 FWD 111.91 51.46 111.91 49.18 下载:
导出CSV
表 4优化后元件的失效率
Table 4.Optimized failure rate of each component
Fit 元件 n 13 14 15 电网侧 IGBT 72.92 × 4 42.17 × 4 35.36 × 4 FWD 342.38 × 4 293.61 × 4 274.44 × 4 牵引侧 IGBT 1 141.30 × 4 546.46 × 4 383.18 × 4 FWD 951.55 × 4 458.38 × 4 322.09 × 4 直流支撑电容 268.04 × 12 221.37 × 12 186.80 × 12 串联电抗器 51.00 × 1 控制底板 150.00 × 2 总失效率 13 600.08 8 369.92 6 652.88 下载:
导出CSV
-
李群湛. 论新一代牵引供电系统及其关键技术[J]. 江南娱乐网页版入口官网下载安装学报,2014,49(4): 559-568.doi:10.3969/j.issn.0258-2724.2014.04.001LI Qunzhan. On new generation traction power supply system and its key technologies for electrification railway[J]. Journal Southwest Jiaotong University, 2014, 49(4): 559-568.doi:10.3969/j.issn.0258-2724.2014.04.001 夏焰坤,李群湛,邹大云. 一种基于有源滤波器的同相牵引供电方案[J]. 电网技术,2010,34(10): 131-134.XIA Yankun, LI Qunzhan, ZOU Dayun. A co-phase traction power supply system based on active power filter[J]. Power System Technology, 2010, 34(10): 131-134. YANG S, BRYANT A, MAWBY P, et al. An industry-based survey of reliability in power electronic converters[J]. IEEE Transactions on Industry Applications, 2011, 47(3): 3151-3157. 周雒维,吴军科,杜雄,等. 功率变流器的可靠性研究现状及展望[J]. 电源学报,2013,1(1): 1-15.ZHOU Luowei, WU Junke, DU Xiong, et al. Status and outlook of power converter’s reliability research[J]. Journal of Power Supply, 2013, 1(1): 1-15. 杜雄,李高显,李腾飞,等. 一种用于提高风电变流器中功率器件寿命的混合空间矢量调制方法[J]. 中国电机工程学报,2015,35(19): 5003-5012.DU Xiong, LI Gaoxian, LI Tengfei, et al. A hybrid modulation method for improving the lifetime of power modules in the wind power converter[J]. Proceeding of CSEE, 2015, 35(19): 5003-5012. 杨珍贵,杜雄,孙鹏菊,等. 风电全功率变流器参数对可靠性的影响分析[J]. 电工技术学报,2015,30(16): 137-145.doi:10.3969/j.issn.1000-6753.2015.16.018YANG Zhengui, DU Xiong, SUN Pengju, et al. Analysis of effect of the converter parameters on full-rated wind power converters reliability[J]. Transactions of China Electrotechnical Society, 2015, 30(16): 137-145.doi:10.3969/j.issn.1000-6753.2015.16.018 吴军科.非平稳工况变流器IGBT模块结温平滑控制研究[D]. 重庆: 重庆大学, 2015. 刘飞,解绍锋,侯东光,等. 基于器件结温的同相补偿变流器可靠性评估[J]. 电力自动化设备,2018,38(1): 149-155.LIU Fei, XIE Shaofeng, HOU Dongguang, et al. Reliability evaluation of co-phase compensation converter based on junction temperature of devices[J]. Electric Power Automation Equipment, 2018, 38(1): 149-155. 陈民武,宋雅琳,刘琛,等. 同相供电系统潮流控制器可靠性建模与冗余分析[J]. 电网技术,2017,41(12): 4022-4029.CHEN Minwu, SONG Yalin, LIU Chen, et al. Reliability modeling and redundancy analysis of power flow controller in co-phase power supply system[J]. Power System Technology, 2017, 41(12): 4022-4029. CHEN Minwu, LI Qunzhan, CLIVE R, et al. Modelling and performance analysis of advanced combined co-phase traction power supply system in electrified railway[J]. IET Generation Transmission and Distribution, 2016, 10(4): 906-916.doi:10.1049/iet-gtd.2015.0513 鲁宗相,刘文华,王仲鸿. 基于k/n(G)模型的 STATCOM 装置可靠性分析[J]. 中国电机工程学报,2007,27(13): 12-17.LU Zhongxiang, LIU Wenhua, WANG Zhonghong. Reliability evaluation of STATCOM based on thek-out-of-n: G model[J]. Proceedings of the CSEE, 2007, 27(13): 12-17. 陈民武,蒋汶兵,王旭光,等. 高速铁路新型同相贯通供电方案及其仿真研究[J]. 铁道学报,2016,38(1): 28-34.doi:10.3969/j.issn.1001-8360.2016.01.005CHEN Minwu, JIANG Wenbing, WANG Xuguang, et al. Study on scheme and simulation of new co-phase continuous traction power supply system for high-speed railway[J]. Journal of the China Railway Society, 2016, 38(1): 28-34.doi:10.3969/j.issn.1001-8360.2016.01.005 D’ARCO S, UNDELAND T M, BOHLLANDER M, et al. A simplified algorithm for predicting power cycling lifetime in direct drive wind power systems[C]// 2012 9th International Multi-Conference on Systems, Signals and Devices (SSD), Chemnitz: IEEE, 2012: 1-6 WEI Lixiang, KERKMAN R J, LUKASZEWSK R A. Evaluation of power semiconductors power cycling capabilities for adjustable speed drive[C]// IEEE Industry Applications Society (ISA) Annual Meeting. Alberta: [s.n.], 2008: 1-10. 潘略武,徐政,张静,等. 电压源换流器型直流输电换流器损耗分析[J]. 中国电机工程学报,2008,28(21): 7-14.PAN Luewu, XU Zheng, ZHANG Jing, et al. Dissipation analysis of VSC-HVDC converter[J]. Proceedings of the CSEE, 2008, 28(21): 7-14. 宋雅琳. 同相供电装置可靠性评估及改善措施研究[D]. 成都: 江南娱乐网页版入口官网下载安装, 2018. 张丽艳,李群湛,朱毅. 新建电气化铁路牵引负荷预测[J]. 江南娱乐网页版入口官网下载安装学报,2016,51(4): 743-749.doi:10.3969/j.issn.0258-2724.2016.04.020ZHANG Liyan, LI Qunzhan, ZHU Yi. Prediction of traction load for new electrified railway[J]. Journal Southwest Jiaotong University, 2016, 51(4): 743-749.doi:10.3969/j.issn.0258-2724.2016.04.020 韩旭东,王斌,高仕斌,等. 基于车网耦合的高速铁路AT供电系统谐振特性[J]. 江南娱乐网页版入口官网下载安装学报,2014,49(4): 582-589.doi:10.3969/j.issn.0258-2724.2014.04.004HAN Xudong, WANG Bin, GAO Shibin, et al. Harmonic resonance of AT power supply system of high speed railway based on train-network coupling[J]. Journal Southwest Jiaotong University, 2014, 49(4): 582-589.doi:10.3969/j.issn.0258-2724.2014.04.004 TSENG H K, KAO S W, CHENG F Y, et al. Analytical solution to harmonic characteristics of three-phase PWM inverter using 3-D modulation model[J]. Electric Power Components and Systems, 2004, 32(11): 1105-1120.doi:10.1080/15325000490441381 张庭场,耿光飞. 基于改进粒子群算法的中压配电网无功优化[J]. 电网技术,2012,36(2): 158-162.ZHANG Tingchang, GENG Guangfei. Reactive power optimization for medium voltage distribution network based on improved particle swarm optimization[J]. Power System Technology, 2012, 36(2): 158-162. 刘琛,陈民武,宋雅琳,等. 高速铁路接触网系统风险评估与维修计划优化[J]. 铁道科学与工程学报,2017,14(2): 205-213.doi:10.3969/j.issn.1672-7029.2017.02.001LIU Chen, CHEN Minwu, SONG Yalin, et al. Research on optimization of maintenance plan for high-speed railway catenary system based on risk assessment[J]. Journal of Railway Science and Engineering, 2017, 14(2): 205-213.doi:10.3969/j.issn.1672-7029.2017.02.001 唐斌.同相供电补偿变流器[D]. 成都: 江南娱乐网页版入口官网下载安装, 2016. ARENDT W, ULRICH N, WERNER T, et al. Application manual power semiconductors[EB/OL]. (2015-10-28)[2017-12-15].http://www.semikron.com -
下载:
点击查看大图
图(12)/
表(4)
计量
- 文章访问数:743
- HTML全文浏览量:322
- PDF下载量:24
- 被引次数:0